全文预览已结束
下载本文档
版权说明:本文档由用户提供并上传,收益归属内容提供方,若内容存在侵权,请进行举报或认领
文档简介
STAR BRITE PLUS TRAFFIC PAINT(Fast-Drying, Acrylic Latex-based traffic & Line Marking Paints)GENERALSTAR-BRITE PLUS TRAFFIC PAINTS are a new generation of water-borne traffic paints which combine the fast-drying properties equivalent to those of solvent-based traffic paints and the safety in handling of latex-based paints. They are suitable for all interior and exterior applications, on asphalt and concrete surfaces.Formulated with 100% ACRYLIC emulsion, a well balanced blend of pigments and co-solvents, STAR BRITE PLUS TRAFFIC PAINTS offer;* Fast drying. Have been approved by various states. Excellent for night time application.* Excellent durability and color retention.* Excellent adhesion to glass beads.* Non-bleeding performance.* Bright highly visible lines with solid hiding power.* Low toxicity, Low Volatile Organic Content ( V. O. C. ) per gallon. Low air pollution.* Low ammability.* Ease in application and clean-up, water- reducible.STAR BRITE PLUS TRAFFIC PAINTS are especially formulated to dry much faster than conventional water-based paints. Under most conditions these paints dry in less than 15 minutes when applied properly.Additionally, STAR BRITE PLUS TRAFFIC PAINTS are adequately suited to be hot-applied for even faster drying times, to meet various state striping specifications. The heat system must be designed to prevent paint temperatures in excess of 155 Deg. F. at any time.RECOMMENDED USESRoad surfaces, parking lots, play areas, traffic islands, airfield marking, running tracks, etc.STAR-BRITE PLUS Traffic paints are ideal for night time striping of fast food restaurants and other commercial lots.SPECIFICATIONS ConstantsYellowWhiteLatex BinderAcrylicAcrylicViscosity, Kus b 77 Degrees F.80-9080-90Weight per Gallon, Lbs.13.6213.57Solids, % by weight75.075.4Solids, % by volume57.658.4Pigment, % by weight58.758.9Acrylic Solids, % by weight39.640.0Reflectance, Minimum50%84%Volatile Organic Content (V.O.C.)/Gal.0.7 Ib.0.65 Ib.Flash Point, Degree F. Tag Closed Cup method101101Dry Opacity, Minimum0.950.95Dilution Rate:None. Ready to use as supplied. Reduce with clean potable water, if needed. The drying time will be delayed by the inclusion of additional water.Coverage Rate:For 15 mils wet or 8-9 mils dry film thickness:Approximately 107 Sq. Ft. per gallon2 inch wide stripe - 650 linear feet.4 inch wide stripe - 325 linear feet.APPLICATION Method:Air or airless spray striping equipment, brush or roller.For Preheated applications, heat the paint to 140 Degree F. then apply with air or airless spray equipment.Any equipment that comes in contact with the paint must be made of stainless steel. Paint holding tank may be epoxy lined. No brass fittings and lines shall be used as they may result in paint destabilization.Surface Preparation:Observe general cleaning practices to remove dirt and debris and ensure that the surface is dry prior to striping.Oil and grease spots shall be sealed with S.O.S. Primer / Sealer.Asphalt must have weathered to rid of the surface oils. Concrete must be etched and thoroughly rinsed with water.Application:Thoroughly mix the contents in the can and apply on a properly prepared surface, Ensure the proper coverage rates.Do not apply if rain is in the forecast within 6 hrs. and ambient/surface temperature is below 50 Degree F.Wash Thinner:Wash tools immediately with water followed by a mixture of 50:50 (by volume) of Methanol and Methyl Ethyl Ketone.PRECAUTIONS* Keep away from sparks, open flame and heat.* Use with adequate ventilation and avoid inhalation of dry over spray.* Avoid prolonged or repeated contact with skin. Use of protective gloves and goggles isrecommended.* Keep the partially used containers tightly
温馨提示
- 1. 本站所有资源如无特殊说明,都需要本地电脑安装OFFICE2007和PDF阅读器。图纸软件为CAD,CAXA,PROE,UG,SolidWorks等.压缩文件请下载最新的WinRAR软件解压。
- 2. 本站的文档不包含任何第三方提供的附件图纸等,如果需要附件,请联系上传者。文件的所有权益归上传用户所有。
- 3. 本站RAR压缩包中若带图纸,网页内容里面会有图纸预览,若没有图纸预览就没有图纸。
- 4. 未经权益所有人同意不得将文件中的内容挪作商业或盈利用途。
- 5. 人人文库网仅提供信息存储空间,仅对用户上传内容的表现方式做保护处理,对用户上传分享的文档内容本身不做任何修改或编辑,并不能对任何下载内容负责。
- 6. 下载文件中如有侵权或不适当内容,请与我们联系,我们立即纠正。
- 7. 本站不保证下载资源的准确性、安全性和完整性, 同时也不承担用户因使用这些下载资源对自己和他人造成任何形式的伤害或损失。
最新文档
- 安徽黄山导游词12篇
- 辽宁省抚顺市第三职业中学高三数学理上学期摸底试题含解析
- 自习睡觉检讨书12篇
- 鲁科版高中化学选择性必修第二册知识点复习资料
- 老师我爱您11篇
- 奋斗青春的演讲稿3篇
- 房产销售工作总结3篇
- 应急物资管理制度6篇
- 新课程标准下高中英语深度学习构建策略分析 论文
- 学生会干事的年终工作总结3篇
- 江苏省2024届高考数学模拟试题(二)(含答案)
- 土地复垦工程施工组织设计完整版样本
- 2023年山东省威海市中考地理试卷
- 新生儿臂丛神经损伤护理查房
- 2024年01月河南省西平县委巡察办所属事业单位2024年公开选聘3名工作人员笔试历年高频考题(难、易错点荟萃)答案带详解附后
- 2023年12月河北环境工程学院招考聘用26人笔试历年高频考题(难、易错点荟萃)答案带详解附后
- 部编版五语下 20《金字塔》核心素养分层作业学习任务单(含答案)
- 人教版八年级信息技术下册全册教案
- 林业人工智能与数字化技术应用
- 水蛭养殖可行性报告
- 无锡灵山小镇·拈花湾-案例分享课件
评论
0/150
提交评论